Welcome to the North American Subaru Impreza Owners Club Wednesday September 17, 2014
Home Forums WikiNASIOC Products Store Modifications Upgrade Garage
NASIOC
Here you can view your subscribed threads, work with private messages and edit your profile and preferences Home Registration is free! Visit the NASIOC Store NASIOC Rules Search Find other members Frequently Asked Questions Calendar Archive NASIOC Upgrade Garage Logout
Go Back   NASIOC > NASIOC Technical > Normally Aspirated Powertrain

Welcome to NASIOC - The world's largest online community for Subaru enthusiasts!
Welcome to the NASIOC.com Subaru forum.

You are currently viewing our forum as a guest, which gives you limited access to view most discussions and access our other features. By joining our community, free of charge, you will have access to post topics, communicate privately with other members (PM), respond to polls, upload content and access many other special features. Registration is free, fast and simple, so please join our community today!

If you have any problems with the registration process or your account login, please contact us.
* Registered users of the site do not see these ads.
 
 
Thread Tools Display Modes
Prev Previous Post   Next Post Next
Old 12-12-2012, 08:03 PM   #1
LeadFootedRacer
Scooby Newbie
 
Member#: 340448
Join Date: Dec 2012
Thumbs down '93 Impreza 'L' EJ18 woes

Bought the car about 5 years ago, and its been a great running, extremely reliable DD. Sold the car to my sister a few years ago. Car now has 188k miles on it. She complained of a horrendous misfire and a noise from the engine. i went over to check it out. the drivers side front spark plug fell apart and seems to have made its way into the crank case and developed a noise in the bottom end. the cause of the misfire was never found, as i threw in a new plug to see if it would change and it did not. I assumed the cylinder was shot and recommended swapping the motor.

I sourced out a used motor from a junkyard who claimed the motor "ran nice" with 104k miles on it.

9 hours, a few torn knuckles, and it was swapped. The only difference between the engines was mine is an automatic, versus the brand-new-used one being from a manual. I swapped the needed parts around no issue.

Now here is my issue. I got everything buttoned up, and gave her a nice once-over before putting in the battery. I installed new belts, hoses, spark plugs, oil change, and exhaust gaskets. Put the battery in and turned the key and it didn't start.

The engine cranks nice and fast, has fuel, but no spark at the coil. I checked the obvious things like missed connections and poor grounds. I then proceeded, 1 at a time, to change (with the ones from the original motor) the coil pack, crank sensor, and cam sensor. Still got nothing. Pulled the end covers off the timing belt, and checked the timing of the engine, and it too checked to be ok.

I have read that low oil pressure could be the cause, key on i get the idiot light on the dash, crank the engine the light goes out, and stays out for a few seconds after you release the key. This leaves me to assume the engine is getting the appropriate oil pressure.

I have also read that the ECU commonly goes bad during a motor swap (how, i have no clue), but i get the CEL on the dash, and being OBDI i cannot scan it.

I did not remove or unplug the ignitor during the swap, therefore i do not suspect this to be the issue.

i unplugged the coil from the harness and get 12v key on power to the middle (red) wire, but appears as though i am getting no crank trigger signal.

My next place to look will be behind the crank pulley, to see if the crank is damaged where the sensor reads. I have read on this forum elsewhere that it was a problem for someone, although their vehicle was far newer than this one.

Do any of you guys have any other suggestions?
LeadFootedRacer is offline   Reply With Quote
 

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump


All times are GMT -4. The time now is 08:45 AM.


Powered by vBulletin® Version 3.7.0
Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Powered by Searchlight © 2014 Axivo Inc.
Copyright ©1999 - 2014, North American Subaru Impreza Owners Club, Inc.